CALL US: 800-937-2326 | PARTS: 800-937-2311  

Used komatsu WA700-3

  • OVERVIEW
  • INSPECTION REPORT
Features
  • EROPS
  • AIR CONDITIONER
  • COUNTERWEIGHT
  • STEER, S.T.I.C.
  • DIFFERENTIAL, STANDARD
  • ENGINE ENCLOSURES
  • LIGHTING
  • AM FM RADIO
GENERAL APPEARANCE
S.O.S. Taken: No (No component sampling taken during this inspection, but highly recommended. Last engine service done on 3/16/2016 with 35,126 hours.)
Cleaning Required: Yes
Rear Frame: Good
Steps / Ladder: Fair (Right front ladder is bent on the bottom. Both rear lower steps are slightly bent and the right side has frayed belts.)
Front Frame: Fair (Weld repairs have been done to the front frame on the top, but has a crack again.)
Paint: Poor (Faded paint with scrapes and scratches. Also there's large amount of lime accumulation throughout the machine.)
Differential Supports: Good
Fenders: Good (Minor dents on both front fenders.)
Counterweight: Good (Rear towing pin is missing.)
Radiator Grill & Shroud: Fair (Radiador grill has few slightly bent fins.)
Cab or Canopy: Good
Crankcase Guard / Battery Box: Good
Eng. Enclose Hood / Stack: Fair (Radiator enclosure is loose on the right lower side and has few cracks.)
Fuel Tank: Fair (Fuel tank has large dents on the bottom.)
Guards / Screens: Fair (Transmission belly guard is dented with missing the drain plug access plate and the rear section of the guard. Engine belly guard plate is missing.)
Sheet Metal: Fair (Engine enclose side panels have minor dents and cracks with some missing some retaining hardware. Right upper engine side access panel has broken hinge.)
SAFETY ITEMS
Safety Decals In Place: Yes
ROPS: Yes (ROPS have been removed for transport.)
Horn: Good (OE horn has been replaced with smaller aftermarket.)
GAUGES, OPERATOR STATION, CONSOLE
Seat Cushion / Arm Rest: Fair (Right arm rest is worn. Non-OE brackets have been welded to the front sides of the seat frame/suspension.)
Meter: Good
Seat Belt: Poor (No dates on seat belt. Belt is also starting to fray.)
Dash Console: Fair (Dash console trim has few cracks and loose panels.)
Glass/Mirrors: Good
EMS Panel / Warnings: Good
Floor Boards: Good
Interior Lights: Good
Doors: Good
Windshield Wipers: Poor (Front wiper motor was not functioning properly during this inspection (Stays on all the time). Wiper washers are not spraying fluid.)
Switches: Good
Windows: Fair (Left door window motor stops operating at times.)
Gauges: Good
Door Latches: Good
Air Conditioner: Poor (A/C wasn't cooling during this inspaection.)
Current O&MM: No (Missing O&M manual.)
Back Up Alarm: Yes
Sound Proofing: No
Current Parts Manual: No
Current Safety Manual: Yes
ENGINE
Fuel Injection System: Fair
Turbocharger / Blower: Fair (Turbo to muffler connector has small exhaust leaks.)
Air Cleaners: Good
Exhaust / Muffler: Good
Belts / Pulleys: Fair (A/C compressor belt missing rib pieces. All other belts have visible wear.)
Operating Condition: Fair (Engine started and operated, but has some abnormal noises during operation (unknown the source). Also felt a bit sluggish during machine driveability test.)
Governor: Fair
Engine Supports: Good
Fluid Levels OK?: No (Very low engine oil level.)
Compression in Radiator: No
Blow By: No
EPA Decal: Yes
Water in Oil: No
Oil Leaks: No (No major engine oil leaks found during this inspection, but there are few oil seepages on various locations of the engine.)
COOLING SYSTEM
Leaks: No (No cooling system leaks found during this inspection. )
Coolers: Good
Fan Drive: Good
Radiator: Good
Fan: Good
Water Pump: Good
Hoses: Good
ELECTRICAL, STARTING AND CHARGING SYSTEM
Block Heater: No
Ether Aid: No
Lighting: Poor (Right front fender mounter, front cab mounted and rear flood lights are inoperable. Tail lights are operational, but are dimmed. ROPS lights were not tested.)
Wiring: Good
Alternator: Good
Batteries / Cables: Fair (Battery cable terminals are missing protecting shields.)
Starter: Good
TRANSMISSION
Transmission - Noisy: No
Transmission - Forward Shifts: Fair
Cooler: Good
Case: Good
Transmission - Reverse Shifts: Fair (Machine will not shift pass 2nd gear (unknown the cause).)
Torque Converter: Good
Lines / Fittings: Fair (Several transmission oil lines have small oil leaks.)
Universal Joints: Good
Operating Condition: Fair (Machine shifted through 1st and second gears only normally without any abnormal noises during limited checks at low speeds, without a load.)
Drive Shaft: Good
STEERING
Valves: Good
Steering Cylinder: Fair (Play at the steering cylinders connecting pins.)
Steering Linkage: Good
Articulate P & B: Good
Lines / Fittings: Fair (One of the steering hoses on the left side of the transmission has a oil leak.)
BRAKE
Lines: Good
Control Valve: Good
Parking Brake: Good
Pedal: Good
Leaks: No (No service brake system oil leaks found during this inspection.)
Holds In Park: Yes
HYDRAULICS
Bucket & Hoist Kickout: Good
Tilt Cylinder: Good
Tank: Good
Lift Cylinders: Good
Pumps & Valves: Good
Hose Lines: Good
Overall Operating Condition: Good (Hydraulic system functioned during a limited checks without a load.)
BUCKET
Cutting Edges: Fair (Many bucket front wear plates are cracked.)
Bucket Bottom: Good
Bucket Floor: Fair (Bucket floor liner has excess wear on the bottom.)
Bucket Sides: Good
Bucket Linkage: Fair (Play at the bucket and tilt linkage connecting pins.)
Teeth / Adapters: Fair (Many bucket teeth have excess wear.)
Loader Frame: Good
FINAL DRIVES
Leaks: No (No axles, finals or differentials oil leaks found during this inspection.)
Trunion: Fair (Visible movement on the rear differential mounting trunnion. Grease line on the rear side of the rear differential trunnion is disconnected.)
Rear Final Drives: Good
Rear Axle: Good
Wheel Lugs & Rims: Good
Differentials: Good
Front Final Drives: Good
Front Axle: Good
Oscillation: Good
TIRES
COMMENTS, MISC. REPAIRS, GENERAL REMARKS